[Mk2] [Turbo] do I need to buy a boost controller before I have a turbo back system fitted
Moderators: IMOC Moderators, IMOC Committee Members
[Mk2] [Turbo] do I need to buy a boost controller before I have a turbo back system fitted
I heard that when you fit a de cat/downpipe , there's an increase in boost pressure , which could cause overboosting , so do you need a boost controller to basically set the level right again. or will it be safe to run the turbo back system anyway without a boost controller.
Re: [Mk2] [Turbo] do I need to buy a boost controller before I have a turbo back system fitted
a boost controller cant turn the boost down like that, can only raise it, if you wanted to fit anything, you would need a restrictor ring in the exhaust so you dont see boost creep.
Re: [Mk2] [Turbo] do I need to buy a boost controller before I have a turbo back system fitted
so is it safe to run then without a boost controller
Re: [Mk2] [Turbo] do I need to buy a boost controller before I have a turbo back system fitted
yes as the boost controller wouldnt be able to help the situation atall
Re: [Mk2] [Turbo] do I need to buy a boost controller before I have a turbo back system fitted
mr2rev3 wrote:yes as the boost controller wouldnt be able to help the situation atall
It was just that i read a post on another mr2 forum where someone was going to fit a downpipe and some guy's response was that you could end up overbooosting and bang there goes your engine in those words .
the boost increase isn't that much is it
Re: [Mk2] [Turbo] do I need to buy a boost controller before I have a turbo back system fitted
i ran my last turbo with a decat etc and was fine, it will most likely raise the boost abit but cant see it being much, is just the same as people raising the boost, what rev do you have?
Re: [Mk2] [Turbo] do I need to buy a boost controller before I have a turbo back system fitted
Jesus stop scaring the guy to death dont post if u aint clued up.
By fitting a aftermarket downpipe and exhaust ur boost pressure will increase slightly.
With a 3 inch diameter downpipe and exhaust and no big engine mods you aint gunna get boost creep
You have a inbuilt FCD so you aint gunna go out and hit 2 bar over night
The only danger with cheap downpipes is the wastegate catching on the downpipe flange dont buy a cheap one and ur be ok
By fitting a aftermarket downpipe and exhaust ur boost pressure will increase slightly.
With a 3 inch diameter downpipe and exhaust and no big engine mods you aint gunna get boost creep
You have a inbuilt FCD so you aint gunna go out and hit 2 bar over night
The only danger with cheap downpipes is the wastegate catching on the downpipe flange dont buy a cheap one and ur be ok
Re: [Mk2] [Turbo] do I need to buy a boost controller before I have a turbo back system fitted
thebody wrote:
The only danger with cheap downpipes is the wastegate catching on the downpipe flange dont buy a cheap one and ur be ok
Re: [Mk2] [Turbo] do I need to buy a boost controller before I have a turbo back system fitted
Fuel cut will save you on a rev1 before anything bad happens with the mods you describe. You may want to consider an uprated intercooler in the future if you are going to turn the boost up. Best bet though is start saving for a rev3+ rather than spending loads on a rev1.
If you search you will see loads of talk about tuning and what is safe.
If you search you will see loads of talk about tuning and what is safe.
Apexi Induction, Gutted Cat, Departure Exhaust, Magnecor Leads, St205 cc, Blitz ebc.
Carbotech pads.
Carbotech pads.
Re: [Mk2] [Turbo] do I need to buy a boost controller before I have a turbo back system fitted
mr2rev3 wrote:a boost controller cant turn the boost down like that,
Yes it can, when you run a boost controller you can set the boost to the level determined by the spring fitted in the actuator, usually around 7psi on a standard turbo.